How to check the oil in the Daewoo Nexia gearbox

Checking the level and changing the oil in a manual transmission Daewoo Nexia N150

Tools:
Parts and consumables:

Notes:

Check and, if necessary, replenish the oil level in the gearbox every 10 thousand kilometers or 6 months. operation.

Check the oil level in the gearbox no earlier than two minutes after stopping the engine. Carry out the work on an inspection ditch or overpass.

Checking the gearbox oil level

1. Using a 13 mm spanner, unscrew the inspection hole plug located next to the inner joint of the right wheel drive in the gearbox housing and remove it.

2. Insert your finger into the hole and check the oil level.

Note:

The normal oil level is at the bottom edge of the hole.

3. If there is insufficient oil, remove the breather cap.

4. Unscrew the breather with a 17 mm wrench and remove it from the hole in the gearbox housing.

5. Clean the metal trap of the transmission inspection plug.

6. Use a syringe to add oil to the Nexia gearbox to the bottom edge of the inspection hole (see point 2). As soon as the oil starts to come out through the inspection hole

7. Tighten the breather and inspection hole plug.

Changing the oil in the Nexia gearbox

Note:

The Daewoo Nexia N150 gearbox is filled with oil for its entire service life. Only the instructions are silent about the length of the period, so presumably it is 100-150 thousand km, or 7-10 years of operation. In any case, even on a new car, it is recommended to replace the mineral water poured into the box with synthetic water.

Even during the operation of the car, it may be necessary to drain the oil and replace it, for example, when repairing a gearbox or when there is a significant oil leak from the gearbox, when it is not possible to add oil of the same brand that was poured into the gearbox. It is recommended to change the oil when the gearbox is warm.

1. Clean the bottom cover of the gearbox from dirt. Place a wide container with a capacity of at least 3.5 liters under the lid.

2. Using a 13 mm socket, unscrew the ten bolts securing the cover partly and drain the oil into a substitute container.

3. After draining the oil, completely unscrew the bolts and remove the cover. Clean it from deposits, wear products of gearbox parts and traces of the old gasket, and also clean the mating surface of the gearbox housing.

4. Then put the gear in neutral, chock the rear wheels, apply the parking brake and jack up the front left wheel to drain any remaining oil from the 5th gear housing.

Note:

You need to jack it high (to the height of the jack, maybe even more). Rotate the left front wheel backwards, and more old oil will spill out.

In this way, approximately 1.7 liters are drained, with a total volume of oil poured into the gearbox of 1.8 liters.

5. Lower the car.

6. Replace the transmission cover gasket with a new one.

7. Screw in the bolts and tighten them evenly to the specified torque.

8. Fill the transmission oil into the gearbox to the required level, as described in the first part of the article.

The article is missing:

Source

And a little about the author’s secrets

My life is not only connected with cars, but with repairs and maintenance. But I also have hobbies like all men. My hobby is fishing.

I started a personal blog in which I share my experience. I try a lot of things, different methods and methods to increase my catch. If interested, you can read it. Nothing extra, just my personal experience.

Attention, TODAY only!

How to change the gearbox oil on a Daewoo Lanos or Daewoo Nexia?

You will find the answer to this question if you click the more details button. Since the gearbox

on the
Daewoo Lanos and Daewoo Nexia
, it does not provide for an oil change, but it needs to be replaced, then when purchasing transmission oil (2 liters), you also need to buy a gasket for the bottom cover of the box (gearbox housing).
If for some reason there is no gasket, then you will have to get silicone sealant. The catalog number of the gearbox housing gasket for Daewoo Lanos, Daewoo Nexia, Chevrolet Lanos is 96179241.
Separately, a few words
on the choice of oil for the gearbox of Daewoo Lanos and Daewoo Nexia cars
. The manufacturer recommends using SAE 80W GL-4 gear oil

, when operating a car in climatic conditions where the ambient temperature remains below -30 for a long time, it is recommended to fill in
75W-90 GL-4
.
That is, you can fill in both mineral water 80W90 GL-4 and synthetics or semi-synthetics 75W-90, 75W80, 80W85 GL-4. For example, I fill the gearbox of my Nexia with 80W GL-4 mineral water. I also tried synthetic 75W-90. Excellent oil, especially in winter, but in summer there is a small minus - noise in the box. Not strong, but there. That's why I switched to the oil recommended by the factory.

Now, step by step - Changing the gearbox oil on a Daewoo Lanos and Daewoo Nexia:

1. Unscrew the bottom cover of the gearbox

and carefully drain the oil from the box (photo 1) (if there is no new gasket available, then the covers must be removed as carefully as possible to avoid damaging the old gasket).

2. When the oil has completely drained, wipe the bottom of the box and the bottom cover with a dry cloth, removing traces of old oil and dirt.

3. After the bottom cover is installed (we use sealant when installing the old gasket), find the oil level control plug next to the internal drive (photo 2) and unscrew it. From the top of the box we look for the oil filler plug, carefully remove the plastic cap from it and unscrew it (photo 3).

4. Next, using an oil blower or syringe, pump transmission oil into the filling hole (photo 4) until oil begins to flow out of the control hole. We first tighten the control hole plug, and then the fill hole plug. Don’t forget, before doing this, clean the plug from dirt and put a protective cap on it (photo 5). It is not recommended to install and use the plug without a protective cap, since it simultaneously serves as a breather.

According to the manufacturer, an oil change in the Daewoo Nexia gearbox is not required during the entire period of operation of the car. However, he does not clarify how long this period is and how to check whether the lubricant has been used up or not. But the lack of lubrication in the gearbox can cause serious problems, as a result of which a complete repair of the gearbox will have to be carried out. And, as you know, it is expensive. To avoid this situation, it is recommended to change the lubricant in the Daewoo Nexia every 100 thousand kilometers. It is worth checking the oil level periodically.

We recommend: Which is better - overhaul or contract engine

It is almost impossible to determine what kind of oil the manufacturer poured into a car’s gearbox at the factory. But most often this “consumable” turns out to be mineral. And it thickens quite strongly at subzero temperatures. So if you are planning a replacement, it is better to buy semi-synthetic or synthetic lubricant.

Periodically, approximately every 15 thousand kilometers, it is necessary to check the level of consumables. As already mentioned, on the Daewoo Nexia the gearbox oil change is not provided for the entire time the car is used. But there are situations when there is a need for replacement. For example, when repairing a gearbox or when transferring a car to a new “consumables”. If a replacement is planned, then the old fluid should be drained while it is hot. This way it will be more fluid.

Replacement frequency

The manufacturer claims that oil is poured into the Daewoo Nexia gearbox for the entire period of operation of the car, but does not specify exactly how long this service life should be and how to check whether it has expired or not. Therefore, in order to avoid serious financial costs for gearbox repairs, it is recommended to change the gearbox oil every 100 thousand km. mileage If you have difficulty shifting gears in cold weather, you can change the oil in the box even before the mileage reaches 100 thousand.

How much should I fill?

It is equally important for owners of these car models to know how many liters are poured into the transmission. Service books for cars that require replacement of this consumable usually contain a table with fill parameters. In the case of an 8- or 16-valve Nexia, there is no such information in the service manual. However, before changing, you need to consider how much lubricant to pour into the gearbox.

As for volume, the transmission of the Daewoo Nexia should contain about 1.8 liters of oil.

Engine	L.S.	Years of manufacture	Oil volume in manual transmission	Automatic transmission oil volume
1,5	75	1995-2008	1.8 l	3.5 l
1.5i 16V DOHC	85/90	2002-2008	1.8 l	3.5 l
1,6	109	2008	2 l	3.5 l

Getting ready for replacement

The motor lubricant in the Daewoo Nexia engine, regardless of how many valves it has, needs to be changed every 10,000 kilometers, but in our conditions this period should be halved, that is, after 5,000 kilometers. Also, when changing engine lubrication, it will not be superfluous to replace the oil filter, regardless of how many valves there are in the engine.

How much oil to pour?

On average, a replacement will require about 3.75 liters of oil for an 8-valve and 16-valve power unit. In a word, buy a four-liter canister at the store.

What kind of oil should I use?

The choice of lubricant brand is individual, there are no restrictions, and it is better to give preference to brands with a better reputation, but the oil must meet the following conditions:

Domestic oils can also be used if they meet the required specifications.

History of Nexia

This Korean middle-class car was presented to the public in 1986. The development was carried out by German specialists (). The car was created on the basis of the Opel Kadett E, which was widespread at that time.

"Nexia" began to be produced for residents of developing countries. Since 1995, cars have become available to citizens of the former Soviet Union. By the way, this car is known to Korean residents under the name “Daewoo Cielo”.

Ergonomics of Daewoo Nexia

The car stood out, first of all, for its low price. It cost no more than Russian front-wheel drive VAZs. The car was quite reliable, unpretentious in use, was ahead of Russian cars in terms of these characteristics and was not inferior to imported middle-class models.

Replacing broken parts was easy due to their availability. All this explains the ubiquity of this machine.

However, Nexia gradually began to lose ground. The last car of this model was released four years ago. After this, the Korean manufacturer began producing the Daewoo Gentra.

Useful tips

It is almost impossible to check what exactly is poured into the gearbox at the factory, but most often this oil turns out to be mineral oil, which thickens quite strongly in winter. When planning a replacement, it is recommended to purchase synthetic or semi-synthetic gearbox oil.

From time to time, at least once every 15 thousand km. mileage, you should check the lubricant level in the gearbox. The design of the Daewoo Nexia gearbox does not provide for lubricant replacement throughout its entire service life. However, sometimes the need for replacement still arises - in the case of a gearbox repair, when switching to a lubricant with a different viscosity, and in other similar situations. When planning a replacement, it is advisable to drain the old lubricant in a warm and fluid state, that is, within 10-15 minutes from the end of the trip.

Consequences of untimely replacement

8- and 16-valve Daewoo Nexia requires periodic replacement of transmission oil, since the additive package in the lubricant loses its properties over time. As a result, it becomes inoperable. Because of this, the liquid cannot provide the proper level of protection for rubbing surfaces. The loss of basic properties will lead to foaming of the working substance, which will ultimately cause scuffing of the main gear. As a result, the gears of the transmission differential will begin to hum, that is, the operation of the gearbox will be accompanied by a hum.

After 500-1000 km, the teeth on the gears will be destroyed. And this will lead to the transmission jamming. The driver will not be able to engage one or more gears. In Nexias with automatic transmissions, oil is also used to cool the unit. Failure to change the lubricant in a timely manner will result in kicks and jolts when shifting gears.

Checking the gearbox oil level

Before you begin inspection, you need to place the vehicle on a level surface. Parking on a slope will significantly distort the parameters and lead to a violation of the operating mode.

In the cold

Used when the vehicle design does not provide otherwise. Most often this happens on manual transmissions. In winter, when there is severe frost, the readings are distorted, so it is better to use a heated garage or a warm box for inspection.

Much depends on the quality of the transmission fluid. Low-grade ones significantly change their viscosity when frozen. High-quality ones, for example, Hessol, maintain indicators within the established criteria and make it possible to perform testing in natural conditions.

Hot

The method is accurate. The lubricant occupies the working position and is evenly distributed over the rubbing surfaces of bearings and gears, covers the shafts and protects them from rapid abrasion.

You can find out the oil level in the gearbox in this way, both manually and automatically. In the latter case, this is the most common option.

Due to high temperatures, inspection using a test plug is not possible. If you do not have a dipstick on your vehicle, then the test is carried out cold or using sensors of electronic systems with subsequent output to the dashboard.

According to the control plug

Quite an outdated technique. Mainly used on trucks or cars with manual gear shift. Due to the fact that there are no bright yellow and orange labels on the case, this method causes the most misunderstanding. Most people have a question about how and where to check the oil level in the gearbox. You can do this using this quick guide:

Which one should I use?

Accordingly, the Daewoo Nexia gearbox can be filled with both mineral oil 80W90 GL-4 and synthetic or semi-synthetic oil 75W80, 75W90, 80W85 GL-4. One of the best options can be considered 80W GL-4. Synthetic lubricant 75W80 is also excellent, especially in winter. In summer, this oil leads to noise in the gearbox, so it is still better to use oils recommended by the manufacturer.

The volume of oil that must be poured into the gearbox is 1.8 liters.

Gear oil for gearbox LIQUI MOLLY (SAE 80W GL-4)

Which oil is better to choose?

When changing the oil in a Daewoo Nexia n150 gearbox with 8 or 16 valves, you need to know what kind of lubricant should be poured into the system. The manufacturer does not regulate this replacement. Accordingly, you will not be able to find information about choosing a product in the service book. Practice shows that Daewoo Nexia gearboxes whose owners fill with synthetic or semi-synthetic lubricant last a long time. Initially, when a car is manufactured, mineral oil is used in the gearbox, so when buying a car it is also better to change it to “synthetic” or “semi-synthetic”.

If the climate in your region is moderate, then you can safely use any oil of the SAE 80W GL-4 standard. When operating a car in severe frost conditions, it is better to give preference to the 75W90 GL-4, proven by car enthusiasts. This lubricant is especially suitable for northern regions, where the average air temperature throughout the year is -25 degrees. It is possible to use both synthetic and semi-synthetic oils, but for cold climates “synthetics” are better suited. The use of such fluid in the warm season can lead to noise in the transmission.

Transmission fluid MANNOL Hypoid Getriebeoel 80W-90 API

Tools

In order to replace the fluid in the gearbox of a Daewoo Nexia, you will need the following tools and accessories:

In order to choose the right gasket, it is first recommended to inspect the transmission pan from below. This is due to the fact that there are two types of pallets, having 10 or 11 holes - the number of holes must be checked before purchasing a gasket. In addition, you don’t have to buy a gasket, but remove the pan and cut it out yourself from paronite, or simply replace it with a sealant, which in practice copes well with the task.

Replacing engine fluid

First, check that the Daewoo Nexia is parked on a level surface. Replacement in the engine is carried out in a pit or overpass. If this does not work, then we jack up the car, observing safety precautions.

What tools should you have on hand?

Replacing daewoo nexia engine fluid - process

Take a look at the light bulb that monitors your blood pressure. If it goes out 20 seconds after turning it on, then everything is fine. If not, then turn off the engine and find out the cause of the problem. Also check the oil level. If the permissible value is exceeded, then drain the excess. If it is lower, add more. Inspect the car and the area underneath it. Check that nothing is leaking anywhere. Take a closer look at the lubricant used. The color should be uniform. If sand or chips are present, sound the alarm, as these are the very first signs of engine trouble.

The process of changing the lubricant in a light car engine

There should be no rings from the cooled liquid on the base of the used motor fluid. The composition should be viscous and thick. It is important to properly dispose of used liquid. If there is a stain in the area where the repair was carried out, be sure to use sand.

Daewoo Nexia engine lubrication has its own characteristics. It is necessary to check the dipstick in the engine when the vehicle is parked on a level surface. When turning on the engine, turn it off and wait 5 minutes before checking. Such a pause is necessary so that the liquid gets into the daewoo nexia engine crankcase.

Regular contact of exposed areas of the body with used lubricant contributes to various skin diseases: dermatitis, skin tumors. Avoid additional contact with liquid and wash your hands thoroughly after the event.

How to correctly check the volume and level of oil in a gearbox (gearbox)

There are no difficulties in the process, but there are a number of methods that radically distinguish the inspection:

The temperature at which you perform the service can have a critical impact. The measurement indicators will differ radically. When the vehicle is warm, the contents of the gearbox from the pan spread over all components, bearings and gears. Significantly less petroleum products remain below. When cooling, on the contrary, the operating fluid tends downwards and increases the filling level.

Modern machine devices make it possible to check the oil level in two ways, but when it’s hot, the readings will be much more accurate. In cold weather without warming up, it is not recommended to carry out control at all. Data may be greatly distorted. At subzero temperatures, transmission lubricant quickly thickens and a significant amount of it remains on the walls and parts without ever getting into the crankcase.

The technology should be clarified according to the service book or operating instructions. There is a universal way to do this without resorting to additional reference books. Remove the dipstick from the gearbox housing and inspect it carefully. There are several options for displaying the level:

If you need to track oil products in the crankcase on a warm unit, it is not enough to start the engine and let it run. The gears remain stationary. You need to drive the car, or switch the handle to all positions in place if we are talking about an automatic machine.

Source

How to change the oil in a Daewoo Nexia gearbox yourself

If you are the owner of a Daewoo Nexia car, you may encounter a problem such as a lack of technical information regarding the frequency of oil changes in the Daewoo Nexia gearbox.

Indeed, in the instructions, the manufacturer clearly indicates that the volume of transmission fluid will ensure correct operation of the gearbox throughout its entire operating life. Unfortunately, even if you try to re-read these lines several times, you still won’t find a word about when this operational period ends.

We will try to help you in this matter by providing useful information to increase your knowledge regarding the operation of individual important components and mechanisms of your car.

The oil change in the Daewoo Nexia gearbox should be carried out after 60 - 100 thousand kilometers.

Change of oil

Some motorists prefer to perform such manipulations almost immediately after purchasing a car, despite the extremely low mileage. They argue for their actions by the fact that oil could have been filled at the factory, accompanied by technical characteristics that do not suit the car owner.

What's the result?

As you can see, the procedure for replacing transmission fluid (oil) in a Daewoo Nexia car is quite simple. Knowing how much oil to fill, its type and characteristics, as well as having an idea of how this procedure is carried out, the car owner can perform the replacement with his own hands.

The main thing is to fill in high-quality gearbox oil with suitable properties, and when replacing, do not allow the oil level in the gearbox to drop or leaks after unscrewing the inspection hole plugs or pan.

How to choose oil for a manual transmission. Changing the oil in a manual transmission, frequency and features of changing transmission oils in a manual transmission.

When to change the gearbox oil: manual and automatic. Types of transmission oils, service life, methods for changing manual and automatic transmission oils, tips.

When and why you need to change the oil in the variator. Features of the variator, methods for changing the oil in a CVT variator. How to change the oil in a CVT yourself.

How to change the oil in a Renault Duster gearbox. Why do you need a replacement when it’s best to change the oil in the Duster box? Recommendations.

How to change the oil in a robotic box: when a change is needed, what oil to choose, how much oil is needed in the robot box. The process of changing the oil in a manual transmission.

How to change the oil in a DSG gearbox: changing the oil in a DSG gearbox. What to consider when replacing, selecting oil for DSG, tips and tricks.

Changing the oil in the Daewoo Nexia gearbox

Which one should I use?

The volume of oil that must be poured into the gearbox is 1.8 liters.

Gear oil for gearbox LIQUI MOLLY (SAE 80W GL-4)

Tools

In order to replace the fluid in the gearbox of a Daewoo Nexia, you will need the following tools and accessories:

Instructions

Changing the oil in the gearbox is carried out on an overpass or pit. The replacement procedure includes the following steps.

1-3 steps 4-7 steps 8 step 9-11 steps

At this point, replacing the fluid in the Daewoo Nexia gearbox can be considered complete. There is nothing complicated about this, all that remains is to check and make sure that the gears change easily enough, regardless of the time of year.

instructions from TANTOA

If you have any questions, or you couldn’t understand the text instructions, we suggest watching our video.

Did you carry out the replacement yourself?

And a little about the author’s secrets

My life is not only connected with cars, but with repairs and maintenance. But I also have hobbies like all men. My hobby is fishing.

Attention, TODAY only!

How to change the gearbox oil on a Daewoo Lanos or Daewoo Nexia?

You will find the answer to this question if you click the more details button. Since the gearbox

, when operating a car in climatic conditions where the ambient temperature remains below -30 for a long time, it is recommended to fill in
75W-90 GL-4
. That is, you can fill in both mineral water 80W90 GL-4 and synthetics or semi-synthetics 75W-90, 75W80, 80W85 GL-4. For example, I fill the gearbox of my Nexia with 80W GL-4 mineral water. I also tried synthetic 75W-90. Excellent oil, especially in winter, but in summer there is a small minus - noise in the box. Not strong, but there. That's why I switched to the oil recommended by the factory.

Now, step by step - Changing the gearbox oil on a Daewoo Lanos and Daewoo Nexia:

1. Unscrew the bottom cover of the gearbox

and carefully drain the oil from the box (photo 1) (if there is no new gasket available, then the covers must be removed as carefully as possible to avoid damaging the old gasket).

2. When the oil has completely drained, wipe the bottom of the box and the bottom cover with a dry cloth, removing traces of old oil and dirt.

We recommend: 4th generation HBO for cars: 7 advantages of use

How to change the oil in a Daewoo Sens gearbox. Level check

Daewoo Sens cars with MeMZ 307 and MeMZ 317 1.3 and 1.4 liter engines are equipped with a domestic Melitopol gearbox. It proved to be quite reliable and unpretentious, but sensitive to the oil level.

It has been noticed that if you use cheap oils and do not monitor the level, the box begins to howl. Second or third gear may also be difficult to engage for the same reason. To extend the service life of the gearbox, it is necessary to monitor the oil level and change it regularly.

How much oil is in the Daewoo Sens gearbox, when to change it

The Sens gearbox is identical in design to the unit that was installed on Tavria and Slavuta, so you can’t expect any tricks from it. The fundamental differences between the boxes are only in the gear ratios and gear shift mechanism. The latter is completely taken from the senior Lanos.

The factory capacity of the gearbox, regardless of engine size, is 2.45 liters.

This volume corresponds to the geometric center of the inner CV joint oil seal hole and the lower edge of the control filler hole.

An oil change is carried out at a mileage of no more than 30,000 km, and it is advisable to check the level every 10,000 miles. In addition, it is necessary to pay attention to the condition of the drive seals. At the first signs of drips in the area of the axle shafts, the seals are replaced with new ones.

In addition, the gearbox input shaft oil seal may leak; drips in the lower part of the crankcase will tell you about this, but it leaks extremely rarely and can easily withstand more than 150 thousand mileage.